TE在电源管理系统的保护解决方案.ppt
《TE在电源管理系统的保护解决方案.ppt》由会员分享,可在线阅读,更多相关《TE在电源管理系统的保护解决方案.ppt(45页珍藏版)》请在得力文库 - 分享文档赚钱的网站上搜索。
1、TE在电源管理系统的保护解决方案,Shanghai Application TeamShanghai Circuit Protection Components Test LaboratorySep. 2011,2019年10月23日星期三,page 2 /,议程,TE 电路保护及新产品简介PPTC在电源管理系统中的过流保护方案 气体放电管在电源管理系统中的防浪涌保护方案 AC2 Pro在电源管理系统中的综合保护方案 PolyZen在电源管理系统中的综合保护方案 2410SFV保险丝在电源管理系统中的保护方案,2019年10月23日星期三,TE 电路保护及新产品简介,TE 优势电路保护产品,O
2、vercurrent CircuitProtection,Overvoltage CircuitProtection,HybridProtection,PolySwitch Resettable Devices,Surface-mount Chip Fuses,2Pro Devices,PolyZen Devices,PESDProtection Devices,Gas Discharge Tubes,Silicon ESDProtection Devices,OvertemperatureProtection,RTP Devices,Telecom Fuses,MHP Devices,Bim
3、etal TP,1980年,业界首家创新式地成功使用聚合物正温度系数材料(PPTC)作为可恢复过流保护器件于电子电路中。帮助许许多多电子设备制造厂商,使其设备更加安全、可靠。致力于创新标准的应用,广泛地提供客户定制型电路保护解决方案。过流保护PolySwitch 自恢复保护器件表面贴式保险丝过压保护ESD 保护器件陶瓷气体放电管综合保护2Pro 器件PolyZen 器件,TE电路保护市场30年,2019年10月23日星期三,PPTC在电源管理系统中的过流保护方案,PPTC技术及PolySwitch元件,PPTCPPTC (Polymer Positive Temperature Coeffic
4、ient 高分子正温度系数)PPTC元件 (高分子正温度系数热敏元件) PolySwitch元件一种高品质的PPTC元件过流/过热保护元件可多次使用,PPTC技术,PolySwitch典型工作电路,正 常 状 态 I=V/RL,RL,动 作 状 态 I=V/RS,Log RS,T,RS,电 源,RL,PPTC技术,用途及用法过流保护(短路保护,过载保护);与被保护部分串联过热保护;与易过热器件热连接优势内阻小且稳定性好纯电阻(10MHz以下)动作速度快表面温度低,LED lighting driver over current protection,LED lighting driver wi
5、ll use AC/DC, DC/DC Power SuppliesNeed the PPTC to protect in the power supply side for fault: short circuit protection, over current protection,Design case : LED Lighting,Part Numbers: LVR016Functional Area: LED short protectionLEDs can fail short caused by improper connection. Protection Type: ove
6、r current protectionWorking conditions: 240VAC, 80mA(60C)A LED rating is 3V. The LEDs will be connected 48pcs in series. It means DC144V, Fault conditions: voltage, 240VAC, 3A(60C),LVR016,2019年10月23日星期三,气体放电管在电源管理系统中的防浪涌保护方案,GDT气体放电管系列GDT for lightning protection,Ceramic GDTs2 and 3 Pole DevicesLead
7、 Types: No Lead, Radial Lead, Axial lead, T LeadDiameter Sizes:6mm, 7.5mm, 8mmDC Sparkover Voltage Values:90V - 3200V8x20s Surge Current Rating (10 times) : 5kA, 10kA, 20kAFail-short Device AvailableAvailable on top and bottom of devicePackagingTrays (Bulk special request),LED照明系统的保护需求,过电压&过电流故障来源:雷
8、电: 直击雷蕴含极大的能量 (峰值电压可达5000kv):雷电击中线路或因电磁感应产生的极高电压,由室外电源线路和通信线路传至室内的电气设备。云层之间频繁放电产生强大的电磁波导致共模和差模干扰,影响电气设备运行。供电系统中的电感性和电容性负载开启或断开、地极短路、电源线路短路等,都能在电源线路上产生高压或高流脉冲 (可达正常电压的3到5倍). 静电供电系统不稳定系统过热故障来源:散热系统不足或失败外部环境温度过高,雷击保护要求- IEC61000-4-5(GB/T 17626.5),GDTs & MOVs Can Protect AC Power-lines Against Voltage S
9、pikes,Input waveform with GDT+MOVs,Input waveform w/o GDT+MOVs,Vpeak,Vclamping,In case the AC line current would be greater than the GDT follow-on current, the MOV avoids any latch of the GDT, and protects it from overheating.,LED照明系统电路的板级雷击浪涌保护 IEC61000-4-5 lightning compliance,应用: 室外照明浪涌防护 职能范围: 交
10、流输入电源的雷击浪涌保护 保护方式: 电源电压: 230VAC 故障条件: 雷击浪涌差模 2KV 1.2/50(8/20), 共模4KV 1.2/50(8/20)雷击浪涌保护,Application: DC power supply protection up to 72VdcAC power supply protection up to 144VacFEATURES: Directly used on AC and DC power, no MOV needFast response timeHigh current rating, space savingStable performan
11、ce over lifeVery low capacitanceHigh insulation resistanceExcellent SMD handling,Stacked GDT for AC/DC power supply Protection,Equivalent circuit,Application for stacked GDT,Key application requirements: Strict height and PCB space limitation for application High exposure lightning strikes requireme
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- te 电源 管理 系统 保护 维护 解决方案
限制150内